LITMIR.BIZ

Скачать книгу

second, introducing grades so steep that the amount of traffic does not authorize the use of engines heavy enough to work them.

      The direction of the traffic, to a certain extent, determines the rate and direction of the inclines. Thus, the Reading Railroad, from Philadelphia up the Schuylkill to Reading, and thence to Pottsville, is employed entirely in the transport of coal from the Lehigh coal-fields to tide-water in Philadelphia; and it is a very economically operated road, considering the large amount of ascent encountered, because the load goes down hill, and the weight of the train is limited only by the number of empty cars that the engine can take back.

      This adoption of steep inclines may be considered as an American idea entirely, and to it many of our large roads owe their success. The Western Railroad of Massachusetts ascends from Springfield to Pittsfield, for a part of the way, at 83 feet per mile. The New York and Erie Railroad has grades of 60 feet per mile. The Baltimore and Ohio climbs the Alleghanies on inclines of 116 feet per mile. The Virginia Central Road crosses the Blue Ridge by grades of 250 and 295 feet per mile; and the ridge through which the Kingwood Tunnel is bored, upon the Baltimore and Ohio Railroad, was surmounted temporarily by grades of 500 feet per mile, up which each single car was drawn by a powerful locomotive.

      Another element, of which American engineers have freely availed themselves, is curvature. More power is required to draw a train of cars around a curved track than upon a straight line. In England the radius of curvature is limited to half a mile, or thereabouts. The English railway-carriage is placed on three axles, all of which are fixed to the body of the vehicle; the passage of curves, of even a large diameter, is thus attended by considerable wear and strain; but in America, the cars, which are much longer than those upon English roads, are placed upon a pintle or pin at each end, which pin is borne upon the centre of a four-wheeled truck,—by which arrangement the wheels may conform to the line of the rails, while the body of the car is unaffected. This simple contrivance permits the use of curves which would otherwise be entirely impracticable. Thus we find curves of one thousand feet radius upon our roads, over which the trains are run at very considerable speed; while in one remarkable instance (on the Virginia Central Railroad, before named) we find the extreme minimum of 234 feet. Such a track does not admit of high speeds, and its very use implies the existence of natural obstacles which prevent the acquirement of great velocities.

      In fine, the use which the engineer makes of grades and curves, when the physical nature of the country and the nature and amount of the traffic expected are known, may be taken as a pretty sure index of his real professional standing, and sometimes as an index of the moral man; as when, for example, he steepens his grades to suit the contractor's ideas of mechanics,—in other words, to save work.

      Not less in the construction of bridges and viaducts, than in the preparation of the road-bed proper, does the American engineering faculty display itself. Timber, of the best quality, may be found in almost every part of the country, and nowhere in the world has the design and building of wooden bridges been carried to such perfection and such extent as in the United States. We speak here of structures built by such engineers as Haupt, Adams, and Latrobe, —and not of those works, wretched alike in design and execution, which so often become the cause of what are called terrible catastrophes and lamentable accidents, but which are, in reality, the just criticisms of natural mechanical laws upon the ignorance of pretended engineers.

      Among the finest specimens of timberwork in America are the Cascade Bridge upon the New York and Erie Railroad, designed and built by Mr. Adams, consisting of one immense timber-arch, having natural abutments in the rocky shores of the creek;—the second edition of the bridges generally upon the same road, by Mr. McCallum, which replaced those originally built during the construction of the road, —these hardly needing to be taken down by other exertion than their own;—the bridges from one end to the other of the Pennsylvania Central Road, by Mr. Haupt;—the Baltimore and Ohio "arch-brace" bridges, by Mr. Latrobe;—and the Genessee "high bridge," (not a bridge, by the way, but a trestle,) near Portageville, by Mr. Seymour, which is eight hundred feet long, and carries the road two hundred and thirty feet above the river, having wooden trestles (post and brickwork) one hundred and ninety feet high, seventy-five feet wide at base, and twenty-five feet at top, and carrying above all a bridge fourteen feet high; containing the timber of two hundred and fifty acres of land, and sixty tons of iron bolts, costing only $140,000, and built in the short time of eighteen months. This structure, if replaced by an earth embankment, would cost half a million of dollars, and could not be built in less than five years by the ordinary mode of proceeding.2

      Further, the interest, for so long a time, on the large amount of money required to build the embankment, at the high rate of railroad interest, would nearly, if not quite, suffice to build the wooden structure.

      Again, our wooden bridges of the average span cost about thirty-five dollars per lineal foot. Let us compare this with the cost of iron bridges, on the English tubular plan, the spans being the same, and the piers, therefore, left out of the comparison.

      Suppose that a road has in all one mile in length of bridges. Making due allowance for the difference in value of labor in England and America, the cost per lineal foot of the iron tubular bridges could not be less (for the average span of 150 feet) than three hundred dollars.

      5280 feet by $35 is $184,800.00

      5280 feet by 300 is $1,584,000.00

      The six per cent. interest on the first is $11,088.00

      The six per cent. interest on the second is $95,040.00

      And the difference is $83,952.00

      or nearly enough to rebuild the wooden bridges once in two years; and ten years is the shortest time that a good wooden bridge should last.

      The reader may wonder why such structures as the bridge over the Susquehanna at Columbia, which consists of twenty-nine arches, each two hundred feet span, the whole water-way being a mile long, and many other bridges spanning large rivers, and having an imposing appearance, are not referred to in this place. The reason is this: large bridges are by no means always great bridges; nor do they require, as some seem to think, skill proportioned to their length. There are many structures of this kind in America, of twenty, twenty-five, or thirty spans, where the same mechanical blunders are repeated over and over again in each span; so that the longer they are and the more they cost, the worse they are. It does not follow, because newspapers say, "magnificent bridge," "two million feet of timber," "eighty or one hundred tons of iron," "cost half a million," that there is any merit about either the bridge or its builder; as one span is, so is the whole; and a bridge fifty feet long, and costing only a few hundreds, may show more engineering skill than the largest and most costly viaducts in America. Few bridges require more knowledge of mechanics and of materials than Mr. Haupt's little "trussed girders" on the Pennsylvania Central Road,—consisting of a single piece of timber, trussed with a single rod, under each rail of the track.

      Again, as regards American iron bridges, the same result is found to a great extent. Thus, Mr. Roebling's Niagara Railroad Suspension-Bridge cost four hundred thousand dollars, while a boiler-plate iron bridge upon the tubular system would cost for the same span about four million dollars, even if it were practicable to raise a tubular bridge in one piece over Niagara River at the site of the Suspension Bridge. Strength and durability, with the utmost economy, seem to have been attained by Mr. Wendel Bollman, superintendent of the road-department of the Baltimore and Ohio Railroad,—the minute details of construction being so skilfully arranged, that changes of temperature, oftentimes so fatal to bridges of metal, have no hurtful effect whatever. And here, again, is seen the distinctive American feature of adaptation or accommodation, even in the smallest detail. Mr. Bollman does not get savage and say, "Messieurs Heat and Cold, I can get iron enough out of the Alleghanies to resist all the power you can bring against me!" —but only observes, "Go on, Heat and Cold! I am not going to deal directly with you, but indirectly, by means of an agent which will render harmless your most violent efforts!"—or, in other words, he interposes a short link of iron between the principal members of his bridge, which absorbs entirely all undue strains.

      It is not to be supposed from what has preceded, that the American engineer does not know how to spend money, because he gets along with so little,

Скачать книгу